Ultrafiltration of ethanol/water extract of Eucalyptus globulus bark: Resistance and cake build up analysis

• Tipo: Artigo em Revista Científica Internacional
• Data: 2015

Autores

Eduarda A. Baptista (Autor) FEUP; Paula C. R. Pinto (Autor) FEUP; Inês F. Mota (Autor) FEUP; José M. Loureiro (Autor) FEUP; Alírio E. Rodrigues (Autor) FEUP

Revista

Título: Separation and Purification Technology

Vol. 144

Páginas: 256-266

ISSN: 1383-5866

Editora: Elsevier

Indexação

ISI Web of Knowledge - 1 Citação

ISI Web of Science

Scopus - 0 Citações

COMPENDEX

Current Contents

Classificação Científica

FOS: Ciências da engenharia e tecnologias > Engenharia química

Projetos Associados

LSRE-LCM - Laboratório de Processos de Separação e Reação - Laboratório de Catálise e Materiais

LA 20 - PROJECTO ESTRATÉGICO - LA 20 - 2013-2014

Outras Informações

ID Authenticus: P-00A-B7M

DOI: 10.1016/j.seppur.2015.02.036

Abstract (EN): Bark from Eucalyptus globulus, a side-stream of pulp and paper industry, is a source of bioactive polyphenols that are extractable with 80/20 (v/v) ethanol/water. In this work, downstream processing of this extract was performed by ultrafiltration (UF) assessing for the first time (i) the influence of membrane type and transmembrane pressure (TMP) on the flux and permeate composition; (ii) the analysis of flux and resistances using the resistance-in-series model; (iii) permeate flux and cake build up modeling; and finally (iv) the feasibility of concentration by UP. Four membranes were selected: polyamide composite GE - 1 kDa (GE 1), polyethersulfone PLEAIDE - 5 kDa (P 5), polyvinylidenefluoride JW - 30 kDa (JW 30), and polysulfone EW - 60 kDa (EW 60). The effect of TMP on the permeation flux was evaluated, and total solids (TS), total phenolic compounds (TPC), proanthocyanidins (Pac) and formaldehyde condensed tannins (fcT) were quantified in the permeates. Data analysis showed that the experiments were performed in a region not controlled by pressure. P 5 and JW 30 membranes are more susceptible to fouling than the GE 1 and EW 60. In spite of the lowest cut-off of GE 1 membrane, it presented the lowest retention to TS, TPC and Pac, demonstrating that membrane material plays a significant role in separation. Finally, a model using classical cake-filtration theory and the surface-renewal concept successfully predicted the permeate flux and cake build up. A trade-off between permeate flux, the resistance and the retentions to TPC and Pac was established. The selected TMP was 3 bar for EW 60 (retentions: TPC 14%, Pac 30%) and 5 bar for JW 30, P 5 and GE 1 (retentions: TPC 66%, 66% and 58%; Pac 87%, 88% and 58%, respectively).

Idioma: Inglês

Tipo (Avaliação Docente): Científica

Nº de páginas: 11